Electronic Throttle Body For VW Transporter T5 & Multivan T5 – OE0280750167 – LOREADA

OE Numbers: 0280750167 / 06A133062AA / 0 280 750 167 / 06A 133 062 AA

Direct OEM Replacement (Bosch) | 12+24 Month Warranty | 100% Factory Tested

Vehicle Fitment – Compatible with:

⚠️ Important: This throttle body is designed for the 2.0L 4-cylinder naturally aspirated petrol engine (EA827/EA113 family) found in early T5 vans. Please verify your original OE number before ordering. Diesel models use different throttle body/air control valves. Engine codes: AXA (primary), also compatible with CJKA, CJKB.

OE Cross Reference – Match with your original part:

ℹ️ This throttle body is manufactured by Bosch, the Original Equipment supplier for VW. The Bosch OE number (0280750167) and VAG number (06A133062AA) reference the same identical part.

Technical Specifications

ℹ️ The integrated TPS (Throttle Position Sensor) and actuator motor are built into this unit and are not serviceable individually – the complete assembly must be replaced.

Product Highlights

✅ Genuine Bosch OEM Quality – Manufactured by Bosch, the original equipment supplier for Volkswagen. Same part as dealer-supplied, without the dealer markup.
✅ OE Fitment – Developed to strict OEM standards. Direct replacement – no wiring modification or splicing required.
✅ Plug & Play Installation – Exact match in dimensions, connector pinouts, and electrical parameters. Uses factory D-shaped 6-pin connector.
✅ High Performance – Motor response time ≤ 50 ms for precise intake control, smooth acceleration, and improved throttle sensitivity.
✅ Reliability – Built-in dual redundant position sensors prevent idle fluctuations, hunting, and false error codes.
✅ Rigorous Testing – 100% factory-tested for thermal cycling, airtightness, and full-stroke angle calibration.
✅ Standard Compliance – Meets ISO 16750 environmental standards for automotive electrical/electronic equipment.
✅ T5/Multivan Optimized – Specifically calibrated for the 2.0L 85kW AXA engine in VW T5 vans, ensuring proper air/fuel mixture for smooth idle and reliable daily driving.

Common Symptoms of a Failing Throttle Body (T5 2.0L Petrol)

• Unstable idle, "hunting," or engine stalling at stops

• Hesitation or flat spot during acceleration

• Check Engine Light (CEL) – common DTCs: P0638, P0697, P2100, P2119, P2120, P2127

• Poor throttle response / delayed acceleration

• Reduced power / limp mode

• Cruise control malfunction (if equipped)

*These symptoms are frequently reported for high-mileage T5 vans when the throttle body components wear out or carbon buildup occurs.*

Installation & Adaptation Tips

IMPORTANT: After replacing the Electronic Throttle Body (ETB) on VW T5 2.0L petrol engines, a throttle self-learning / adaptation procedure is REQUIRED.

Step-by-Step Procedure:

For VW T5 2.0L AXA: The above procedure typically works. If issues persist, use a professional diagnostic scanner (e.g., VCDS / VAG-COM) to perform "Throttle Body Alignment" (Basic Settings Group 060 or 098 in Engine module). After replacement, it may take a few drive cycles for the ECU to fully adapt to the new throttle body.

Packing List

• Electronic Throttle Body Unit (Bosch OEM quality) × 1

• Installation Gasket / Seal (if applicable) × 1

• Warranty Card / Quality Certificate × 1

• (Optional: Screws / Connector protector – may vary by batch)

How to Ensure You Get the Correct Part

1. Confirm your vehicle is a Volkswagen Transporter T5, Multivan T5, or Caravelle T5 (2003–2015).

2. Check your engine is the 2.0L 4-cylinder petrol (engine code AXA, CJKA, or CJKB) – 85kW / 115HP.

3. Verify your vehicle is not a diesel – diesel T5 models use different throttle/intake valves.

4. Locate the original part number (OE) on your existing throttle body.

5. Match your OE number with 0280750167 or 06A133062AA.

6. Contact us with your VIN or a photo of your original part if unsure.

After-Sales & Disclaimer

• Pre-installation check: Inspect the throttle body for any defects. Verify the OE number before installation. Ensure the connector shape matches (D-shape 6-pin).

• Compatibility: This throttle body is for 2.0L naturally aspirated petrol engines ONLY. It will NOT fit T5 diesel models (1.9 TDI, 2.0 TDI, 2.5 TDI) or later T6 models without verification. Early T4 models are not compatible.

• Professional installation recommended: While installation is straightforward, proper adaptation is critical. If you are not comfortable performing the relearn procedure, professional installation is recommended.

• Warranty: This product carries a 12-month warranty against manufacturing defects. The motor and sensors are covered for 24 months.

🛠️ Quick Reference Card (for Print/Inclusion)